甲醇水蒸气重整制氢中Cu-Al尖晶石分级处理：Cu物种调变对缓释催化行为的影响

赵祖锋; 杨明; 吴坤云; 韩蛟; 刘道胜; 张财顺; 张磊; 高志贤

doi:10.12434/j.issn.2097-2547.20260084

您当前的位置：

首页 >

文章列表页 >

甲醇水蒸气重整制氢中Cu-Al尖晶石分级处理：Cu物种调变对缓释催化行为的影响

更新时间：2026-06-08

- 甲醇水蒸气重整制氢中Cu-Al尖晶石分级处理：Cu物种调变对缓释催化行为的影响
- Classification treatment of Cu-Al spinel for hydrogen production by methanol steam reforming: Effects of Cu species modulation on slow-release catalytic behaviors
- 低碳化学与化工 2026: 1-10.
- 作者机构：
  
  1.辽宁石油化工大学石油化工学院，辽宁抚顺 113001
  2.中石油昆仑燃气有限公司安徽分公司，安徽合肥 230041
  3.中石化（河南）炼化有限公司，河南洛阳 471012
  4.辽宁石油化工大学理学院，辽宁抚顺 113001
- 作者简介：
  
  赵祖锋（2000—），硕士研究生，研究方向为氢能与催化，E-mail：770537721@qq.com。
  韩　蛟（1986—），博士，讲师，研究方向为氢能与催化，E-mail：hanjiao2011@sina.com
  张　磊（1983—），博士，教授，研究方向为氢能与催化，E-mail：lnpuzhanglei@163.com。
  高志贤（1964—），博士，教授，研究方向为氢能与催化，E-mail：gaozx@lnpu.edu.cn。
- 基金信息：
  
  国家自然科学基金(22379059);辽宁省教育厅基本科研项目(LJ212410148019)
- DOI：10.12434/j.issn.2097-2547.20260084
  中图分类号： TQ426.8
- 收稿：2026-02-24，
  
  修回：2026-03-20，
  
  网络首发：2026-06-05，
- 稿件说明：
移动端阅览
赵祖锋,杨明,吴坤云等.甲醇水蒸气重整制氢中Cu-Al尖晶石分级处理：Cu物种调变对缓释催化行为的影响[J].低碳化学与化工,

ZHAO Zufeng,YANG Ming,WU Kunyun,et al.Classification treatment of Cu-Al spinel for hydrogen production by methanol steam reforming: Effects of Cu species modulation on slow-release catalytic behaviors[J].Low-Carbon Chemistry and Chemical Engineering,
赵祖锋,杨明,吴坤云等.甲醇水蒸气重整制氢中Cu-Al尖晶石分级处理：Cu物种调变对缓释催化行为的影响[J].低碳化学与化工, DOI：10.12434/j.issn.2097-2547.20260084.

ZHAO Zufeng,YANG Ming,WU Kunyun,et al.Classification treatment of Cu-Al spinel for hydrogen production by methanol steam reforming: Effects of Cu species modulation on slow-release catalytic behaviors[J].Low-Carbon Chemistry and Chemical Engineering, DOI：10.12434/j.issn.2097-2547.20260084.

摘要

为探究Cu-Al尖晶石催化剂在甲醇水蒸气重整制氢（MSR）反应中的缓释催化行为，以还原-氧化→酸洗→焙烧的方法对Cu-Al尖晶石催化剂进行了分级处理。通过XRD、H

-TPR和XPS等表征方法分析了催化剂物化性质，并评价了其MSR反应催化性能。结果表明，分级处理可实现催化剂中Cu物种（非尖晶石相、尖晶石相）的可控调变。还原-氧化使尖晶石相Cu含量降低，非尖晶石相CuO分散度提升；酸洗可高效脱除非尖晶石相CuO；焙烧则诱导部分尖晶石相Cu逆向转化为非尖晶石相CuO。同时，分级处理改变了催化剂织构性质，处

理后催化剂缓释特征显著增强。反应50 h后，未处理的CA作用下甲醇转化率升高了5.7%，反应68 h后，甲醇转化率稳定在90.5%。CA-300R-300O、CA-HNO

和CA-HNO

-500作用下初始甲醇转化率分别为57.3%、38.8%和42.8%，反应50 h后甲醇转化率分别升高了28.0%、39.2%和35.2%，并依次在90 h、55 h和60 h后稳定在87.5%、82.2%和83.6%左右。本研究可为高稳定性Cu-Al尖晶石缓释催化剂的结构设计与性能优化提供重要的实验数据与理论依据。

Abstract

To investigate the slow-release catalytic behaviors of Cu-Al spinel catalysts for hydrogen production by methanol steam reforming (MSR)

Cu-Al spinel catalysts were prepared via classification treatment including reduction-oxidation

acid washing and calcination. The physicochemical properties of the catalysts were characterized by XRD

-TPR and XPS

and their catalytic performances for MSR reaction were evaluated. The results demonstrate that classification treatment realizes the controllable modulation of Cu species (non-spinel phase and spinel phase). Reduction-oxidation reduces the content of spinel phase Cu and improves the dispersion of non-spinel phase CuO. Acid washing can efficiently remove non-spinel phase CuO

while calcination induces the reverse transformation of partial spinel phase Cu into non-spinel phase CuO. Meanwhile

classification treatment alters the textural properties of the catalysts

and the slow-release catalytic behaviors of modified catalysts are remarkably strengthened. After 50 hours of reaction

the methanol conversion of the untreated CA catalyst increases by 5.7% and stabilizes at 90.5% after 68 h. The initial methanol conversions of CA-300R-300O

CA-HNO

and CA-HNO

-500 are 57.3%

38.8% and 42.8%

respectively. After 50 hours of reaction

their methanol conversion rates increase by 28.0%

39.2% and 35.2%

and stabilize at about 87.5%

82.2% and 83.6% after 90 h

55 h and 60 h

respectively. This work will provide reliable experimental data and theoretical guidance for the structural design and performance optimization of high-stability Cu-Al spinel slow-release catalysts.

关键词

Keywords

references

TULUHONG A , CHANG Q P , XIE L R , et al . Current status of green hydrogen production technology: A review [J ] . Sustainability , 2024 , 16 ( 20 ): 9070 .

张庆生 , 黄雪松 . 国内外氢能产业政策与技术经济性分析 [J ] . 低碳化学与化工 , 2023 , 48 ( 2 ): 133 - 139 .

ZHANG Q S , HUANG X S . Analysis of domestic and foreign hydrogen energy industrial policies and technical economy [J ] . Low-Carbon Chemistry and Chemical Engineering , 2023 , 48 ( 2 ): 133 - 139 .

ARMAROLI N , BALZANI V . The hydrogen issue [J ] . ChemSusChem , 2011 , 4 ( 1 ): 21 - 36

易宇楠 , 倪雨茜 , 张嘉宁 , 等 . 高熵合金催化剂在电解水制氢和氢燃料电池应用中的研究进展 [J ] . 低碳化学与化工 , 2024 , 49 ( 9 ): 62 - 71 .

YI Y N , NI Y Q , ZHANG J N , et al . Research progress of high-entropy alloy catalysts in water electrolysis for hydrogen production and hydrogen fuel cells [J ] . Low-Carbon Chemistry and Chemical Engineering , 2024 , 49 ( 9 ): 62 - 71 .

吴爽 , 丁巍巍 , 刘瑞 , 等 . 大型海藻微波热解制氢特性研究 [J ] . 低碳化学与化工 , 2024 , 49 ( 1 ): 119 - 124+132 .

WU S , DING W W , LIU R , et al . Study on characteristics of hydrogen production by microwave-assisted pyrolysis of macroalgae [J ] . Low-Carbon Chemistry and Chemical Engineering , 2024 , 49 ( 1 ): 119 - 124+132 .

汪翼东 . 面向PEMFC的甲醇现场重整制氢系统设计与应用研究 [D ] . 杭州 : 浙江大学 , 2019 .

WANG Y D . Design and application study of methanol fuel processing system for PEMFC [D ] . Hangzhou : Zhejiang University , 2019 .

张楷文 , 刘鑫尧 , 张磊 , 等 . 甲醇水蒸气重整制氢Cu-Zn-Al尖晶石催化剂的研究 [J ] . 燃料化学学报 , 2022 , 50 ( 4 ): 494 - 502 .

ZHANG K W , LIU X Y , ZHANG L , et al . Cu-Zn-Al spinel catalyst for hydrogen production from methanol steam reforming [J ] . Journal of Fuel Chemistry and Technology , 2022 , 50 ( 4 ): 494 - 502 .

YANG S Q , ZHO F , LIU Y J , et al . Morphology effect of ceria on the performance of CuO/CeO 2 catalysts for hydrogen production by methanol steam reforming [J ] . International Journal of Hydrogen Energy , 2019 , 44 ( 14 ): 7252 - 7261 .

杨淑倩 , 刘玉娟 , 刘进博 , 等 . 焙烧温度对甲醇水蒸气重整制氢Ce/Cu/Zn-Al水滑石衍生催化剂的影响 [J ] . 燃料化学学报 , 2018 , 46 ( 12 ): 1482 - 1490 .

YANG S Q , LIU Y J , LIU J B , et al . Effect of calcination temperature on the catalytic performance of the hydrotalcite derived Ce/Cu/Zn-Al catalysts for hydrogen production via methanol steam reforming [J ] . Journal of Fuel Chemistry and Technology , 2018 , 46 ( 12 ): 1482 - 1490 .

QIAO W J , YANG S Q , ZHANG L , et al . Performance of Cu-Ce/M-Al (M = Mg, Ni, Co, Zn) hydrotalcite derived catalysts for hydrogen production from methanol steam reforming [J ] . International Journal of Energy Research , 2021 , 45 ( 9 ): 12773 - 12783 .

YU K M K , TONG W Y , WEST A , et al . Non-syngas direct steam reforming of methanol to hydrogen and carbon dioxide at low temperature [J ] . Nature Communications , 2012 , 3 ( 11 ): 1230 .

MA X , YANG W W , TANG X Y , et al . Solar-driven methanol steam reforming for low carbon and efficient hydrogen production: A review [J ] . Journal of Cleaner Production , 2024 , 436 : 140587

XI H J , HOU X N , LIU Y J , et al . Cu-Al spinel oxide as an efficient catalyst for methanol steam reforming [J ] . Angewandte Chemie International Edition , 2014 , 53 ( 44 ): 11886 - 11889 .

张磊 . 甲醇水蒸气重整制氢催化剂的研究 [D ] . 大连 : 大连理工大学 , 2013 .

ZHANG L . Studies on catalysts of methanol steam reforming for hydrogen production [D ] . Dalian : Dalian University of Technology , 2013 .

ARGYLE M , BARTHOLOMEW C H . Heterogeneous catalyst deactivation and regeneration: A review [J ] . Catalysts , 2015 , 5 ( 1 ): 145 - 269 .

乔韦军 , 张楷文 , 张娜 , 等 . 甲醇水蒸气重整制氢CuAl 2 O 4 催化材料的研究 [J ] . 燃料化学学报 , 2020 , 48 ( 8 ): 980 - 985 .

QIAO W J , ZHANG K W , ZHANG N , et al . Study on CuAl 2 O 4 catalytic material for methanol steam reforming [J ] . Journal of Fuel Chemistry and Technology , 2020 , 48 ( 8 ): 980 - 985 .

WANG Z Y , LIANG K , CHAN S W , et al . Fabrication of nano CuAl 2 O 4 spinel for copper stabilization and antibacterial application [J ] . Journal of Hazardous Materials , 2019 , 371 : 550 - 557 .

QIN F J , LIU Y J , QING S J , et al . Cu-Al spinel as a sustained release catalyst for H 2 production from methanol steam reforming: Effects of different copper sources [J ] . Journal of Fuel Chemistry and Technology , 2017 , 45 ( 12 ): 1481 - 1488 .

吕昌赫 , 吴殿卿 , 张楷文 , 等 . Cu-Mn-Al三元尖晶石催化甲醇重整反应特性 [J ] . 石油化工高等学校学报 , 2024 , 37 ( 2 ): 50 - 57 .

LV C H , WU D Q , ZHANG K W , et al . Characteristics of methanol steam reforming catalyzed by Cu-Mn-Al ternary spinel [J ] . Journal of Petrochemical Universities , 2024 , 37 ( 2 ): 50 - 57 .

吴坤云 , 苏实宇 , 王霞 , 等 . 不同处理调变Cu-Al尖晶石催化甲醇水蒸气重整制氢的缓释行为特征 [J ] . 燃料化学学报（中英文） , 2025 , 53 ( 7 ): 1050 - 1060 .

WU K Y , SU S Y , WANG X , et al . Characteristics of the sustained release of Cu-Al spinel pretreated by different methods for hydrogen production from methanol steam reforming [J ] . Journal of Fuel Chemistry and Technology , 2025 , 53 ( 7 ): 1050 - 1060 .

HOU X N , QING S J , LIU Y J , et al . Cu-Al spinel oxide as a sustained release catalyst for methanol steam reforming: Enhancing the catalytic performance via surface reconstruction [J ] . Journal of Fuel Chemistry and Technology , 2024 , 52 ( 1 ): 47 - 53 .

HOU X N , QING S J , LIU Y J , et al . Reshaping CuO on silica to generate a highly active Cu/SiO 2 catalyst [J ] . Catalysis Science & Technology , 2016 , 6 ( 16 ): 6311 - 6319 .

余长林 , 杨凯 , 余济美 , 等 . 稀土Ce掺杂对ZnO结构和光催化性能的影响 [J ] . 物理化学学报 , 2011 , 27 ( 2 ): 505 - 512 .

YU C L , YANG K , YU J M , et al . Effects of rare earth Ce doping on the structure and photocatalytic performance of ZnO [J ] . Acta Physico-Chimica Sinica , 2011 , 27 ( 2 ): 505 - 512 .

QIU X M , YU H , CHEN Y H , et al . Stepwise pyrolysis treatment as an efficient strategy to enhance the stability performance of Fe-N X /C electrocatalyst towards oxygen reduction reaction and proton exchange membrane fuel cell [J ] . Applied Catalysis B: Environmental , 2021 , 295 : 120311 .

李佳祺 , 刘明新 , 初奇瑞 , 等 . 焙烧温度对Ru/CeO 2 催化剂在高通量甲醇水蒸气重整制氢反应中催化性能的影响 [J ] . 低碳化学与化工 , 2025 , 50 ( 3 ): 23 - 29 .

LI J Q , LIU M X , CHU Q R , et al . Effects of calcination temperature on catalytic performance of Ru/CeO 2 catalysts for hydrogen production by high flux steam reforming of methanol [J ] . Low-Carbon Chemistry and Chemical Engineering , 2025 , 50 ( 3 ): 23 - 29 .

LIU Y J , KANG H F , HOU X N , et al . Sustained release catalysis: Dynamic copper releasing from stoichiometric spinel CuAl 2 O 4 during methanol steam reforming [J ] . Applied Catalysis B: Environment , 2023 , 323 : 122043 .

陈泳竹 , 刘道胜 , 赵永福 , 等 . La改性Cu-Al尖晶石催化甲醇水蒸气重整制氢 [J ] . 燃料化学学报（中英文） , 2025 , 53 ( 12 ): 1779 - 1788 .

CHEN Y Z , LIU D S , ZHAO Y F , et al . La-modified Cu-Al spinel catalysts for hydrogen production via methanol steam reforming [J ] . Journal of Fuel Chemistry and Technology , 2025 , 53 ( 12 ): 1779 - 1788 .

PAPAVASILIOU J , AVGOUROPOULOS G , IOANNIDES T . Combined steam reforming of methanol over Cu-Mn spinel oxide catalysts [J ] . Journal of Catalysis , 2007 , 251 ( 1 ): 7 - 20 .

LIU Y J , QING S J , HOU X N , et al . Cu-Ni-Al spinel oxide as an efficient durable catalyst for methanol steam reforming [J ] . ChemCatChem , 2018 , 10 ( 24 ): 5698 - 5706 .

HOU X N , QING S J , LIU Y J , et al . Enhancing effect of MgO modification of Cu-Al spinel oxide catalyst for methanol steam reforming [J ] . International Journal of Hydrogen Energy , 2020 , 45 ( 1 ): 477 - 489 .

浏览量

下载量

CNKI被引量

文章被引用时，请邮件提醒。

提交

工具集

关联资源

钛锰系储氢合金吸放氢及纯化性能仿真研究

减压蒸馏法回收变质胺液及CO2捕集性能研究

生物质基缓释尿素的制备及其缓释性能研究

壁面粗糙度对超音速喷管内部CO2非平衡凝结的影响

Al3+和Ga3+共掺杂CuZn催化剂催化合成气制低碳醇性能研究