Experiment of CO<sub>2</sub> capture by organic amine method under lime rotary kiln real flue gas condition

QIU Zhengqiu; HUANGFU Lin; YANG Qiang; DUAN Xiaodong; YAN Panlin

doi:10.12434/j.issn.2097-2547.20240108

您当前的位置：

首页 >

文章列表页 >

Experiment of CO₂ capture by organic amine method under lime rotary kiln real flue gas condition

- Experiment of CO₂ capture by organic amine method under lime rotary kiln real flue gas condition
- Vol. 49, Issue 7, Pages: 62-68(2024)
- 作者机构：
  
  1.攀钢集团研究院有限公司钒钛资源综合利用国家重点实验室，四川攀枝花 617000
  2.成都先进金属材料产业技术研究院股份有限公司，四川成都 610305
  3.攀钢集团冶金材料有限责任公司，四川攀枝花 617023
- 作者简介：
- 基金信息：
- DOI：10.12434/j.issn.2097-2547.20240108
  CLC： TF044
- Published：25 July 2024，
  
  Received：18 March 2024，
  
  Revised：07 April 2024，
- 稿件说明：
扫描看全文
邱正秋,皇甫林,杨强等.石灰回转窑真实烟气条件下有机胺法CO₂捕集试验[J].低碳化学与化工,2024,49(07):62-68.

QIU Zhengqiu,HUANGFU Lin,YANG Qiang,et al.Experiment of CO₂ capture by organic amine method under lime rotary kiln real flue gas condition[J].Low-carbon Chemistry and Chemical Engineering,2024,49(07):62-68.
邱正秋,皇甫林,杨强等.石灰回转窑真实烟气条件下有机胺法CO₂捕集试验[J].低碳化学与化工,2024,49(07):62-68. DOI： 10.12434/j.issn.2097-2547.20240108.

QIU Zhengqiu,HUANGFU Lin,YANG Qiang,et al.Experiment of CO₂ capture by organic amine method under lime rotary kiln real flue gas condition[J].Low-carbon Chemistry and Chemical Engineering,2024,49(07):62-68. DOI： 10.12434/j.issn.2097-2547.20240108.

摘要

为推动有机胺法CO

捕集工艺在钢铁行业的应用，在石灰石回转窑炉真实烟气条件下开展了有机胺法CO

捕集侧线试验，考察了有机胺溶液质量分数、烟气流量、溶液喷淋量、吸收温度、油浴温度和再生压力等关键参数对捕集系统CO

捕集性能的影响。结果表明，在最优试验条件（有机胺溶液质量分数为25.0%、烟气流量为20 m

/h、溶液喷淋量为70 L/h、吸收温度为30 ℃、油浴温度为115 ℃以及再生压力为10 kPa）下，捕集系统CO

捕集率和解吸酸气量分别为94%和1.22 m

/h。在最优试验条件下进行的480 h连续试验结果显示，捕集系统CO

捕集率平均值为94%，解吸酸气量平均值为1.22 m

/h，CO

捕集系统表现出良好的稳定性，证明有机胺法应用于石灰回转窑烟气CO

捕集技术可行。

Abstract

To promote the application of the organic amine CO

capture process in the steel industry

the sideline test of CO

capture by organic amine method was carried out under lime rotary kiln real flue gas condition. The effects of key parameters such as the mass fraction of organic amine solution

flue gas flow

solution spray amount

absorption temperature

oil bath temperature and regeneration pressure on CO

capture performance of the capture system were investigated. The results show that under the optimal test conditions (the mass fraction of organic amine solution of 25.0%

the flue gas flow of 20 m

the solution spray amount of 70 L/h

the absorption temperature of 30 ℃

the oil bath temperature of 115 ℃ and the regeneration pressure of 10 kPa)

the CO

capture efficiency and the amount of desorption acid gas of the capture system are 94% and 1.22 m

respectively. The results of 480 h continuous test under the optimal test conditions show that the average value of CO

capture efficiency of the capture system is 94%

and the average value of desorption acid gas amount of the capture system is 1.22 m

/h. The CO

capture system shows good stability

which proves that the application of organic amine method to the lime rotary kiln flue gas CO

capture technology is feasible.

关键词

石灰回转窑烟气CO2捕集有机胺吸收法

Keywords

lime rotary kilnflue gasCO2 captureorganic amine absorption method

references

MENG F Z, MENG Y, JU T Y, et al. Research progress of aqueous amine solution for CO2 capture: A review [J]. Renewable & Sustainable Energy Reviews, 2022, 168: 16.

刘志刚. CO2捕集技术的研究现状与发展趋势[J]. 石油与天然气化工, 2022, 51(4): 24-32.

LIU Z G. Research status and development trend of CO2 capture technology [J]. Chemical Engineering of Oil & Gas, 2022, 51(4): 24-32.

陆诗建, 贡玉萍, 刘玲, 等. 有机胺CO2吸收技术研究现状与发展方向[J]. 洁净煤技术, 2022, 28(9): 44-54.

LU S J, GONG Y P, LIU L, et al. Research status and future development direction of CO2 absorption technology for organic amine [J]. Clean Coal Technology, 2022, 28(9): 44-54.

CHEN M J, LUO Q L, LIN H Z, et al. A study on reaction mechanism and kinetics of CO2 and MEA/DEA-tertiary amines in non-aqueous and water-lean solutions [J]. Chemical Engineering Science, 2023, 269: 13.

张欢, 汪丽, 叶舣, 等. 乙二烯三胺与三乙醇胺混合胺溶液CO2吸收剂研究[J]. 发电技术, 2022, 43(4): 609-617.

ZHANG H, WANG L, YE Y, et al. Study on CO2 absorbent of DETA and TEA mixed amine solution [J]. Power Generation Technology, 2022, 43(4): 609-617.

STEPHENNE K. Start-up of world’s first commercial post-combustion coal fired CCS project: Contribution of Shell Cansolv to SaskPower Boundary Dam ICCS project [J]. Energy Procedia, 2014, 63: 6106-6110.

MIYAMOTO O, MAAS C, TSUJIUCHI T, et al. KM CDR processTM project update and the new novel solvent development [J]. Energy Procedia, 2017, 114: 5616-5623.

MANTRIPRAGADA H C, ZHAI H, RUBIN E S. Boundary Dam or Petra Nova—Which is a better model for CCS energy supply? [J]. International Journal of Greenhouse Gas Control, 2019, 82: 59-68.

陆诗建, 黄凤敏, 李清方, 等. 燃烧后CO2捕集技术与工程进展[J]. 现代化工, 2015, 35(6): 48-52.

LU S J, HUANG F M, LI Q F, et al. Advances in technology and project of post-combustion CO2 capture [J]. Modern Chemical Industry, 2015, 35(6): 48-52.

韩涛, 赵瑞, 张帅, 等. 燃煤电厂二氧化碳捕集技术研究及应用[J]. 煤炭工程, 2017, 49(S1): 24-28.

HAN T, ZHAO R, ZHANG S, et al. Research and application on carbon capture of coal-fired power plants [J]. Coal Engineering, 2017, 49(S1): 24-28.

刁保圣, 顾欣, 冯琰磊. 大规模二氧化碳捕集及综合利用示范[J]. 锅炉技术, 2021, 52(6): 76-80.

DIAO B S, GU X, FENG Y L. Large scale carbon dioxide capture and comprehensive utilization demonstration [J]. Boiler Technology, 2021, 52(6): 76-80.

LIU L B, FANG M X, XU S S, et al. Development and testing of a new post-combustion CO2 capture solvent in pilot and demonstration plant [J]. International Journal of Greenhouse Gas Control, 2022, 113: 10.

陆诗建, 刘苗苗, 刘玲, 等. 烟气胺法CO2捕集技术进展与未来发展趋势[J]. 化工进展, 2023, 42(1): 435-444.

LU S J, LIU M M, LIU L, et al. Progress and future development trend of amine method of CO2 capture technology from flue gas [J]. Chemical Industry and Engineering Progress, 2023, 42(1): 435-444.

杜云贵, 刘舒巍, 吴其荣. 火电行业碳捕集技术现状及发展趋势[J]. 中国资源综合利用, 2023, 41(5): 104-107.

DU Y G, LIU S W, WU Q R. Current status and development trends of carbon capture technology in the thermal power industry [J]. China Resources Comprehensive Utilization, 2023, 41(5): 104-107.

邱正秋. 一种烟气脱碳组合物及烟气脱碳的方法: 107398147A [P]. 2017-11-28.

QIU Z Q. A composition and method for removing CO2 from flue gas: 107398147A [P]. 2017-11-28.

邱正秋, 皇甫林. 哌嗪类有机胺溶液捕集CO2性能研究[J]. 石油与天然气化工, 2023, 52(5): 25-29.

QIU Z Q, HUANGFU L. Research on CO2 capture performance of piperazine-based organic amine solution [J]. Chemical Engineering of Oil & Gas, 2023, 52(5): 25-29.

邱正秋, 皇甫林, 刘鹏举, 等. 填料塔中有机胺溶液脱除CO2性能研究[J]. 低碳化学与化工, 2023, 48(2): 121-126.

QIU Z Q, HUANGFU L, LIU P J, et al. Research on CO2 removal performance of organic amine solution in packed tower [J]. Low-Carbon Chemistry and Chemical Engineering, 2023, 48(2): 121-126.

邱正秋, 王建山, 皇甫林, 等. 一种烟气中二氧化碳脱除系统: 117244383A [P]. 2023-12-19.

QIU Z Q, WANG J S, HUANGFU L, et al. A system for removing CO2 from flue gas: 117244383A [P]. 2023-12-19.

NIKOLIC H, FRIMPONG R A, LIU K L. Trace metals accumulation in a coal-fired post combustion CO2 capture process with amine-based solvents [J]. International Journal of Greenhouse Gas Control, 2015, 42: 59-65.

LIU C, ZHAO Z Y, SHAO L Y, et al. Experimental study and modified modeling on effect of SO2 on CO2 absorption using amine solution [J]. Chemical Engineering Journal, 2022, 448: 10.

SCHÄFFER A, BRECHTEL K, SCHEFFKNECHT G. Comparative study on differently concentrated aqueous solutions of MEA and TETA for CO2 capture from flue gases [J]. Fuel, 2012, 101: 148-153.

王乐萌. 新型复配醇胺溶液捕集CO2过程的吸收特性研究[D]. 北京: 华北电力大学（北京）, 2018.

WANG L M. Absorption performance for CO2 capture process using aqueous solutions of novel amine blends [D]. Beijing: North China Electric Power University (Beijing), 2018.

HÜSER N, SCHMITZ O, KENIG E Y. A comparative study of different amine-based solvents for CO2-capture using the rate-based approach [J]. Chemical Engineering Science, 2017, 157: 221-231.

KUNTZ J, AROONWILAS A. Performance of spray column for CO2 capture application [J]. Industrial & Engineering Chemistry Research, 2008, 47(1): 145-153.

王煦清, 严圣林, 朱礼涛, 等. 填料塔中有机胺吸收CO2气液传质的研究进展[J]. 化工学报, 2023, 74(1): 237-256.

WANG X Q, YAN S L, ZHU L T, et al. Research progress on the mass transfer process of CO2 absorption by amines in a packed column [J]. CIESC Journal, 2023, 74(1): 237-256.

TAVAN Y, HOSSEINI S H. A novel application of reactive absorption to break the CO2-ethane azeotrope with low energy requirement [J]. Energy Conversion and Management, 2013, 75: 407-417.

YANG Q, PUXTY G, JAMES S, et al. Toward intelligent CO2 capture solvent design through experimental solvent development and amine synthesis [J]. Energy & Fuels, 2016, 30(9): 7503-7510.

SEMA T, NAAMI A, FU K, et al. Comprehensive mass transfer and reaction kinetics studies of CO2 absorption into aqueous solutions of blended MDEA-MEA [J]. Chemical Engineering Journal, 2012, 209: 501-512.

XIAO M, LIU H, GAO H, et al. CO2 capture with hybrid absorbents of low viscosity imidazolium-based ionic liquids and amine [J]. Applied Energy, 2019, 235: 311-319.

孙路长, 王争荣, 吴冲, 等. 燃煤电厂万吨级碳捕集工程设计与运行优化研究[J]. 华电技术, 2021, 43(6): 69-78.

SUN L C, WANG Z R, WU C, et al. Research on operation optimization of a 10000 t/a carbon capture project for coal-fired power plants [J]. Huadian Technology, 2021, 43(6): 69-78.

张克舫, 刘中良, 王远亚, 等. 化学吸收法CO2捕集解吸能耗的分析计算[J]. 化工进展, 2013, 32(12): 3008-3014.

ZHANG K F, LIU Z L, WANG Y Y, et al. Analysis and calculation of the desorption energy consumption of CO2 capture process by chemical absorption method [J]. Chemical Industry and Engineering Progress, 2013, 32(12): 3008-3014.

汪世清, 刘练波, 王金意, 等. 1000 t/a燃煤烟气CO2捕集装置再生能耗优化试验[J]. 化学工程, 2015, 43(12): 53-57.

WANG S Q, LIU L B, WANG J Y, et al. Optimization on regeneration energy of a 1000 t/a CO2 capture pilot plant [J]. Chemical Engineering (China), 2015, 43(12): 53-57.

LI S M, LI H, YU Y M, et al. Simulation and performance comparison for CO2 capture by aqueous solvents of N-(2-hydroxyethyl) piperazine and another five single amines [J]. Processes, 2021, 9(12): 19.

李虎. 乙醇胺吸收沼气中高浓度CO2的传质性能及工艺优化[D]. 北京: 北京科技大学, 2017.

LI H. Mass transfer performance and process optimization of CO2 absorption by monoethanolamines for biogas purification [D]. Beijing: University of Science and Technology Beijing, 2017.

Views

下载量

CNKI被引量

Alert me when the article has been cited

提交

Tools

Publicity Resources

Research progress of CO₂chemical absorption from flue gas and hydroconversion catalysts

Intensification of CO₂ capture by active sites in functional ionic liquids

Adsorption performance of metal-organic framework/carbon aerogel composite adsorbent for CO₂ in simulated flue gas

Research progress in preparation of fly ash based aluminosilicate materials and their CO₂ capture

Related Author

WANG Yanxia

FU Na

HU Xiude

ZHANG Wei

ZHANG Ruina

GE Chunliang

LI Lai

FAN Wenyang

Related Institution

School of Chemistry and Chemical Engineering, North Minzu University

Key Laboratory for Chemical Engineering and Technology, State Ethnic Affairs Commission, North Minzu University

State Key Laboratory of High-Efficiency Utilization of Coal and Green Chemical Engineering, School of Chemistry and Chemical Engineering, Ningxia University

Ningxia Key Laboratory of Solar Chemical Conversion Technology, North Minzu University

Zhejiang Zheneng Technology & Environment Group Co., Ltd.

Postal code：610225
Tel：028-85964717 Email：dthxyhg@swchem.com
Technical support is provided by Beijing Founder electronics co., LTD 蜀ICP备12008600号-10 蜀公网安备51012202001533
It is recommended to read the content of this site in Chrome&IE9+. Please switch to extreme mode in browser 360.
Cookies We use cookies to help provide and enhance our service and tailor content. By continuing, you agree to the use of cookies.
Total Visits：104521 Visits Today：65

⁰

Experiment of CO2 capture by organic amine method under lime rotary kiln real flue gas condition

DOI：10.12434/j.issn.2097-2547.20240108

摘要

Abstract

关键词

Keywords

references

Experiment of CO₂ capture by organic amine method under lime rotary kiln real flue gas condition