共沉淀法制备Ag-ZrO<sub>2</sub>-SiO<sub>2</sub>催化剂及其乙醇制丁二烯性能研究

柳蒙蒙; 余淦; 贾伯阳; 黄明真; 崔燕冉; 陈亚松

doi:10.12434/j.issn.2097-2547.20250224

您当前的位置：

首页 >

文章列表页 >

共沉淀法制备Ag-ZrO₂-SiO₂催化剂及其乙醇制丁二烯性能研究

更新时间：2026-01-15

- 共沉淀法制备Ag-ZrO₂-SiO₂催化剂及其乙醇制丁二烯性能研究
- Study on preparation of Ag-ZrO₂-SiO₂ catalysts by co-precipitation and their performances in ethanol-to-butadiene
- 低碳化学与化工 2026: 1-7.
- 作者机构：
  
  1.中国长江三峡集团有限公司，湖北武汉 430010
  2.浙江大学生物系统工程与食品科学学院，浙江杭州 310058
  3.浙江大学衢州研究院，浙江衢州 324000
- 作者简介：
  
  柳蒙蒙（1992—），博士，高级工程师，研究方向为污废水处理及资源化利用，E-mail：liu_mengmeng@ctg.com.cn。
  陈亚松（1982—），博士，正高级工程师，研究方向为水环境系统治理，E-mail：chen_yasong@ctg.com.cn。
- 基金信息：
  
  中国长江三峡集团有限公司科研项目资助(NBWL202200489)
- DOI：10.12434/j.issn.2097-2547.20250224
  中图分类号： TQ426.8;O643.36+1
- 收稿：2025-05-14，
  
  修回：2025-06-15，
  
  网络出版：2026-01-15，
- 稿件说明：
移动端阅览
柳蒙蒙,余淦,贾伯阳等.共沉淀法制备Ag-ZrO₂-SiO₂催化剂及其乙醇制丁二烯性能研究[J].低碳化学与化工,

LIU Mengmeng,YU Gan,JIA Boyang,et al.Study on preparation of Ag-ZrO₂-SiO₂ catalysts by co-precipitation and their performances in ethanol-to-butadiene[J].Low-Carbon Chemistry and Chemical Engineering,
柳蒙蒙,余淦,贾伯阳等.共沉淀法制备Ag-ZrO₂-SiO₂催化剂及其乙醇制丁二烯性能研究[J].低碳化学与化工, DOI：10.12434/j.issn.2097-2547.20250224.

LIU Mengmeng,YU Gan,JIA Boyang,et al.Study on preparation of Ag-ZrO₂-SiO₂ catalysts by co-precipitation and their performances in ethanol-to-butadiene[J].Low-Carbon Chemistry and Chemical Engineering, DOI：10.12434/j.issn.2097-2547.20250224.

摘要

开发新型乙醇制丁二烯催化剂是实现传统丁二烯生产路线替代的关键。采用共沉淀法，通过调控Zr前驱体浓度，制备了系列Ag-ZrO

-SiO

催化剂。利用XRD、SEM、N

吸/脱附、元素分析和Py-IR等手段，对催化剂进行了表征，并利用固定床反应器评价了催化剂乙醇制丁二烯催化性能，探究了酸性调控对催化剂催化性能的影响。结果表明，通过调控Zr前驱体浓度，优化催化剂Lewis酸量及其强度分布，可以促进乙醛C—C耦合主反应，同时抑制乙醇脱水生成乙烯等副反应。在温度为420 ℃、重时空速为0.3 h

-1

的反应条件下，AZS-2催化剂（制备过程ZrO(NO

)

溶液质量分数为10%）具有最佳催化性能，其乙醇转化率为80.0%，丁二烯选择性为47.3%，乙烯选择性显著低于其他催化剂。

Abstract

Developing novel ethanol-to-butadiene catalysts is essential for enabling alternatives to the traditional butadiene production route. A series of Ag-ZrO

-SiO

catalysts was prepared using co-precipitation method

in which the Zr precursor concentration was controlled. The catalysts were characterized by XRD

SEM

adsorption/desorption

elemental analysis and Py-IR. Their catalytic performances in ethanol-to-butadiene were evaluated in a fixed-bed reactor to investigate the influence of acidity regulation on catalytic performance. The results show that controlling the Zr precursor concentration optimizes both the amount and strength distribution of Lewis acid sites

which promotes the main C—C coupling reaction of acetaldehyde while suppressing the side reaction of ethanol dehydration to ethylene. Under reaction conditions of 420 ℃ and weight hourly space velocity of 0.3 h

-1

the AZS-2 catalyst (prepared using a 10% mass fraction ZrO(NO

)

solution) exhibits the best catalytic performance

achieving an ethanol conversion of 80.0% and a butadiene selectivity of 47.3%. Its ethylene selectivity is notably lower than that of other catalysts.

关键词

Keywords

references

DE BAERDEMAEKER T , FEYEN M , MÜLLER U , et al . Bimetallic Zn and Hf on silica catalysts for the conversion of ethanol to 1,3-butadiene [J ] . ACS Catalysis , 2015 , 5 ( 6 ): 3393 - 3397 .

QI X Y , GENG J L , ZHAO S Y , et al . Zr-containing deboronated beta zeolite as a catalyst for the 1,3-butadiene obtaining process from an ethanol-acetaldehyde mixture [J ] . Fuel , 2025 , 387 : 134395 .

LI X Q , ZHAO Y J , PANG J F , et al . Recent advances in metal-zeolite catalysts for ethanol to 1,3-butadiene conversion: Active metal sites, mechanisms, and future challenges [J ] . ACS Catalysis , 2025 , 15 ( 6 ): 5053 - 5085 .

WANG K Z , ZHANG W J , GAO W Z , et al . Recent advances in tailor-made catalysts for the direct conversion of ethanol to butadiene [J ] . Fuel , 2024 , 370 : 131872 .

POMALAZA G , PONTON P A , CAPRON M , et al . Ethanol-to-butadiene: The reaction and its catalysts [J ] . Catalysis Science & Technology , 2020 , 10 ( 15 ): 4860 - 4911 .

LATIF M N , WAN ISAHAK W N R , SAMSURI A , et al . Recent advances in the technologies and catalytic processes of ethanol production [J ] . Catalysts , 2023 , 13 ( 7 ): 1093 .

HOANG T D , NGHIEM N . Recent developments and current status of commercial production of fuel ethanol [J ] . Fermentation , 2021 , 7 ( 4 ): 314 .

EDEH I . Bioethanol production: An overview [M ] //INAMBAO F L L. Bioethanol technologies . London : IntechOpen , 2021 : 1 - 22 .

DOCHAIN D D , STYSKALIK A , VYKOUKAL V , et al . Non-hydrolytic sol-gel routes to bifunctional Cu-Ta-SiO 2 catalysts for the upgrading of ethanol to butadiene [J ] . Chemistry of Materials , 2023 , 35 ( 17 ): 7113 - 7124 .

CHUNG S H , LI T , SHOINKHOROVA T , et al . Origin of active sites on silica-magnesia catalysts and control of reactive environment in the one-step ethanol-to-butadiene process [J ] . Nature Catalysis , 2023 , 6 ( 4 ): 363 - 376 .

WANG K Z , GAO W Z , CHEN F , et al . Hierarchical nano-sized ZnZr-Silicalite-1 multifunctional catalyst for selective conversion of ethanol to butadiene [J ] . Applied Catalysis B: Environmental , 2022 , 301 : 120822 .

方文 . 生物乙醇制丁二烯催化剂及工艺技术研究进展 [J ] . 化学工程 , 2023 , 51 ( 12 ): 88 - 94 .

FANG W . Recent developments in catalysts and technology for production of butadiene from bio-ethanol [J ] . Chemical Engineering (China) , 2023 , 51 ( 12 ): 88 - 94 .

WANG C , ZHENG M Y , LI X S , et al . Catalytic conversion of ethanol into butadiene over high performance LiZnHf-MFI zeolite nanosheets [J ] . Green Chemistry , 2019 , 21 ( 5 ): 1006 - 1010 .

陈翀 , 李自琴 , 马盈月 , 等 . 有序介孔二氧化硅负载Zn和Zr多功能催化剂催化乙醇转化制丁二烯性能研究 [J ] . 低碳化学与化工 , 2024 , 49 ( 6 ): 45 - 53 .

CHEN C , LI Z Q , MA Y Y , et al . Study on catalytic performance of ordered mesoporous silica loaded Zn and Zr multifunctional catalysts for direct conversion of ethanol to butadiene [J ] . Low-Carbon Chemistry and Chemical Engineering , 2024 , 49 ( 6 ): 45 - 53 .

LI X Q , PANG J F , ZHAO Y J , et al . Identifying a bi-molecular synergetic adsorption mechanism for catalytic transformation of ethanol/acetaldehyde into 1,3-butadiene [J ] . Chinese Journal of Catalysis , 2025 , 71 : 297 - 307 .

VIEIRA J L , DESTRO P , LAIER L O , et al . MgO/SiO 2 prepared by wet-kneading as a catalyst for ethanol conversion to 1,3-butadiene: Prins condensation as the predominant mechanism [J ] . Molecular Catalysis , 2022 , 532 : 112718 .

ANGELICI C , WECKHUYSEN B M , BRUIJNINCX P C A . Chemocatalytic conversion of ethanol into butadiene and other bulk chemicals [J ] . ChemSusChem , 2013 , 6 ( 9 ): 1595 - 1614 .

ANGELICI C , VELTHOEN M E Z , WECKHUYSEN B M , et al . Effect of preparation method and CuO promotion in the conversion of ethanol into 1,3-butadiene over SiO 2 -MgO catalysts [J ] . ChemSusChem , 2014 , 7 ( 9 ): 2505 - 2515 .

GAO M X , LIU Z Z , ZHANG M H , et al . Study on the mechanism of butadiene formation from ethanol [J ] . Catalysis Letters , 2014 , 144 ( 12 ): 2071 - 2079 .

HUANG X X , MEN Y , WANG J G , et al . Highly active and selective binary MgO-SiO 2 catalysts for the production of 1,3-butadiene from ethanol [J ] . Catalysis Science & Technology , 2017 , 7 ( 1 ): 168 - 180 .

TAIFAN W E , BALTRUSAITIS J . In situ spectroscopic insights on the molecular structure of the MgO/SiO 2 catalytic active sites during ethanol conversion to 1,3-butadiene [J ] . The Journal of Physical Chemistry C , 2018 , 122 ( 36 ): 20894 - 20906 .

KYRIIENKO P I , LARINA O V , BALAKIN D Y , et al . 1,3-Butadiene production from aqueous ethanol over ZnO/MgO-SiO 2 catalysts: Insight into H 2 O effect on catalytic performance [J ] . Applied Catalysis A: General , 2021 , 616 , 118081 .

BOJE A , TAIFAN W E , STRÖM H , et al . First-principles-informed energy span and microkinetic analysis of ethanol catalytic conversion to 1, 3-butadiene on MgO [J ] . Catalysis Science & Technology , 2021 , 11 ( 20 ): 6682 - 6694 .

TAIFAN W E , LI Y Y , BALTRUS J P , et al . Operando structure determination of Cu and Zn on supported MgO/SiO 2 catalysts during ethanol conversion to 1,3-butadiene [J ] . ACS Catalysis , 2018 , 9 ( 1 ): 269 - 285 .

WINKELMAN A D , DAGLE V L , LEMMON T L , et al . Effect of alkali metal addition on catalytic performance of Ag/ZrO 2 /SBA-16 catalyst for single-step conversion of ethanol to butadiene [J ] . Catalysis Science & Technology , 2023 , 13 ( 4 ): 975 - 983 .

BAYLON R A L , SUN J , WANG Y . Conversion of ethanol to 1,3-butadiene over Na doped Zn x Zr y O z mixed metal oxides [J ] . Catalysis Today , 2016 , 259 : 446 - 452 .

ZHAO Y F , JIANG W J , ZHANG J Q , et al . Anchoring sites engineering in single-atom catalysts for highly efficient electrochemical energy conversion reactions [J ] . Advanced Materials , 2021 , 33 ( 41 ), 2102801 .

POMALAZA G , SIMON P , ADDAD A , et al . Properties and activity of Zn-Ta-TUD-1 in the Lebedev process [J ] . Green Chemistry , 2020 , 22 ( 8 ): 2558 - 2574 .

JONES M D , KEIR C G , IULIO C D , et al . Investigations into the conversion of ethanol into 1,3-butadiene [J ] . Catalysis Science & Technology , 2011 , 1 ( 2 ): 267 - 272 .

MENG Y D . A sustainable approach to fabricating Ag nanoparticles/PVA hybrid nanofiber and its catalytic activity [J ] . Nanomaterials , 2015 , 5 ( 2 ): 1124 - 1135 .

LIN F , DAGLE V L , WINKELMAN A D , et al . Understanding the deactivation of Ag-ZrO 2 /SiO 2 catalysts for the single-step conversion of ethanol to butenes [J ] . ChemCatChem , 2020 , 13 ( 3 ): 999 - 1008 .

SATO A G , VOLANTI D P , MEIRA D M , et al . Effect of the ZrO 2 phase on the structure and behavior of supported Cu catalysts for ethanol conversion [J ] . Journal of Catalysis , 2013 , 307 : 1 - 17 .

YANG F , Z 1 HAO H F , WANG W , et al . Atomic origins of the strong metal-support interaction in silica supported catalysts [J ] . Chemical Science , 2021 , 12 ( 38 ): 12651 - 12660 .

SZABÓ B , NOVODÁRSZKI G , LÓNYI F , et al . Texture and morphology-directed activity of magnesia-silica mixed oxide catalysts of ethanol-to-butadiene reaction [J ] . Journal of Molecular Structure , 2022 , 1259 , 132764 .

ALGHANNAM A , BELL A T . Effects of cofeeding hydrogen on propane dehydrogenation catalyzed by isolated iron sites incorporated into dealuminated BEA [J ] . Journal of the American Chemical Society , 2025 , 147 ( 2 ): 1677 - 1693 .

浏览量

下载量

CNKI被引量

文章被引用时，请邮件提醒。

提交

工具集

关联资源

Ce和Mn改性Co/AC催化合成气制低碳醇性能研究

共沉淀法制备Ag-ZrO2-SiO2催化剂及其乙醇制丁二烯性能研究

Study on preparation of Ag-ZrO2-SiO2 catalysts by co-precipitation and their performances in ethanol-to-butadiene

DOI：10.12434/j.issn.2097-2547.20250224

摘要

Abstract

关键词

Keywords

references

共沉淀法制备Ag-ZrO₂-SiO₂催化剂及其乙醇制丁二烯性能研究

Study on preparation of Ag-ZrO₂-SiO₂ catalysts by co-precipitation and their performances in ethanol-to-butadiene