Study on catalytic performances of Cs-Nb/SiO<sub>2</sub> acid-base bifunctional catalysts in aldol condensation to MMA

DING Mingyue; PENG Yingjuan; WANG Guangyong; YAN Yi; YAO Pei; LI Rong; WANG Li; ZHANG Kexian

doi:10.12434/j.issn.2097-2547.20250168

您当前的位置：

首页 >

文章列表页 >

Study on catalytic performances of Cs-Nb/SiO₂ acid-base bifunctional catalysts in aldol condensation to MMA

更新时间：2026-03-19

- Study on catalytic performances of Cs-Nb/SiO₂ acid-base bifunctional catalysts in aldol condensation to MMA
- Vol. 51, Issue 3, Pages: 53-59(2026)
- 作者机构：
  
  西南化工研究设计院有限公司国家碳一化学工程技术研究中心，多孔材料与分离转化全国重点实验室，四川成都 610225
- 作者简介：
- 基金信息：
- DOI：10.12434/j.issn.2097-2547.20250168
  CLC： TQ225;TQ426
- Received：09 April 2025，
  
  Revised：2025-05-23，
  
  Published：25 March 2026
- 稿件说明：
移动端阅览
丁明月,彭颖娟,王光永等.Cs-Nb/SiO₂酸碱双功能催化剂催化羟醛缩合制MMA性能研究[J].低碳化学与化工,2026,51(3):53-59.

DING Mingyue,PENG Yingjuan,WANG Guangyong,et al.Study on catalytic performances of Cs-Nb/SiO₂ acid-base bifunctional catalysts in aldol condensation to MMA[J].Low-Carbon Chemistry and Chemical Engineering,2026,51(3):53-59.
丁明月,彭颖娟,王光永等.Cs-Nb/SiO₂酸碱双功能催化剂催化羟醛缩合制MMA性能研究[J].低碳化学与化工,2026,51(3):53-59. DOI： 10.12434/j.issn.2097-2547.20250168.

DING Mingyue,PENG Yingjuan,WANG Guangyong,et al.Study on catalytic performances of Cs-Nb/SiO₂ acid-base bifunctional catalysts in aldol condensation to MMA[J].Low-Carbon Chemistry and Chemical Engineering,2026,51(3):53-59. DOI： 10.12434/j.issn.2097-2547.20250168.

摘要

羟醛缩合制甲基丙烯酸甲酯（MMA）反应中，催化剂常因积炭而导致稳定性变差。催化剂表面的强酸、强碱性位点是导致催化剂积炭的重要因素，可采用消除催化剂表面强酸、强碱性位点的方法提高催化剂的稳定性。以SiO

为载体，Cs为活性组分，Nb、V或P为活性助剂，制备了一系列酸碱双功能催化剂。采用XRD、TPD和N

吸/脱附等研究了活性助剂种类、Cs含量（

(Cs)/

(载体)）对催化剂晶体结构、酸碱性和织构性质的影响，并研究了催化剂的羟醛缩合制MMA催化性能和稳定性。结果表明，在

(甲醛):

(丙酸甲酯) = 1:3、温度为340 °C、压力为0.2 MPa和原料进料量为0.2 mL/min的条件下反应48 h，Cs含量为10.0%的催化剂（Cs10.0-Nb/SiO

）表现出良好的催化性能，其产物（MMA +甲基丙烯酸）选择性为93.4%，产物收率为21.3%。以NH

选择性覆盖强酸性位点并反应96 h后，Cs10.0-Nb/SiO

的产物收率和产物选择性分别为20.2%和91.5%，略优于原始Cs10.0-Nb/SiO

。

Abstract

During aldol condensation to methyl methacrylate (MMA)

the catalyst often has poor reaction stability due to carbon deposition. The strong acid and strong base sites on surface of the catalyst are important reasons for carbon deposition on catalyst

and the method of eliminating the strong acid and strong base sites on surface of the catalyst can be used to improve stability of the catalyst. A series of acid-base bifunctional catalysts were prepared with SiO

as the support

Cs as the active component and Nb

V or P as the active additives. Effects of types of active additives and Cs contents (

(Cs)/

(support)) on the crystal structures

acidities and alkalinities and textural properties of the catalysts were investigated by XRD

TPD and N

adsorption/desorption

and the catalytic performances and stabilities of the catalysts in aldol condensation to MMA were also studied. The results show that under the conditions of

(formaldehyde):

(methyl propionate) of 1:3

temperature of 340 ℃

pressure of 0.2 MPa and raw material feed rate of 0.2 mL/min for 48 h

the catalyst with Cs content of 10.0% (Cs10.0-Nb/SiO

) demonstrates excellent catalytic performance

with the product (MMA + methacrylic acid) selectivity

of 93.4% and the product yield of 21.3%. After selectively covering strong acid sites with NH

and reacting for 96 h

the product yield and product selectivity of Cs10.0-Nb/SiO

are 20.2% and 91.5%

respectively

slightly better than the original Cs10.0-Nb/SiO

关键词

Keywords

references

肖铭 . 国内外甲基丙烯酸甲酯的生产和消费分析 [J ] . 精细与专用化学品 , 2025 , 33 ( 1 ): 13 - 16 .

XIAO M . Production and consumption analysis of methyl methacrylate at home and abroad [J ] . Fine and Specialty Chemicals , 2025 , 33 ( 1 ): 13 - 16 .

杨钟祥 , 赵在庆 . 丙酮氰醇法和异丁烯法生产MMA技术经济对比 [J ] . 化学工业 , 2015 , 33 ( 1 ): 41 - 44 .

YANG Z X , ZHAO Z Q . Technical and economic comparison between acetone cyanohydrin method and isobutene method for producing MMA [J ] . Chemical Industry , 2015 , 33 ( 1 ): 41 - 44 .

于连生 , 钱庆安 . 基于专利的甲基丙烯酸甲酯技术现状与市场分析 [J ] . 河南科技 , 2024 , 51 ( 5 ): 137 - 141 .

YU L S , QIAN A Q . Technology status and market analysis of methyl methacrylate based on patent [J ] . Henan Science and Technology , 2024 , 51 ( 5 ): 137 - 141 .

三菱化学英国有限公司 . 用于产生烯属不饱和羧酸或羧酸酯的工艺 : 107466289A [P ] . 2021-09-17 .

Mitsubishi Chemical UK Ltd . Process for producing ethylenically unsaturated carboxylic acids or carboxylic acid esters : 107466289A [P ] . 2021-09-17 .

WANG Y N , LANG X W , ZHAO G Q , et al . Preparation of Cs-La-Sb/SiO 2 catalyst and its performance for the synthesis of methyl acrylate by aldol condensation [J ] . RSC Advances , 2015 , 5 ( 41 ): 32826 - 32834 .

赵辉 . 适于丙烯酸甲酯流化床工艺的VPO/ γ -Al 2 O 3 催化剂研究 [D ] . 北京 : 中国科学院大学 , 2017 .

ZHAO H . The study on VPO/ γ -Al 2 O 3 catalyst for methyl acrylate fluidized bed process [D ] . Beijing : University of Chinese Academy of Sciences , 2017 .

左村村 . 改性ZSM-5催化醋酸甲酯-甲醛合成丙烯酸甲酯过程研究 [D ] . 北京 : 中国科学院大学 , 2018 .

ZUO C C . Process research of methyl acrylate synthesis with methyl acetate and formaldehyde over modified ZSM-5 catalysts [D ] . Beijing : University of Chinese Academy of Sciences , 2018 .

XU L , WANG X P , SONG J H , et al . Rational synergetic insight of Cs-Nb/Al 2 O 3 toward promoted catalytic performance in aldol condensation of formaldehyde and methyl propionate [J ] . Chemical Engineering Science , 2025 , 302 : 120781 .

王光永 , 李荣 , 鄢义 , 等 . 羟醛缩合法制甲基丙烯酸甲酯催化剂研究 [J ] . 天然气化工—C1化学与化工 , 2020 , 45 ( 5 ): 1 - 5 .

WANG G Y , LI R , YAN Y , et al . Study on aldol condensation catalyst for methyl methacrylate synthesis [J ] . Natural Gas Chemical Industry , 2020 , 45 ( 5 ): 1 - 5 .

ZHANG G L , ZHANG H H , YANG D , et al . Catalysts, kinetics and process optimization for the synthesis of methyl acrylate over Cs-P/ γ -Al 2 O 3 [J ] . Catalysis Science & Technology , 2016 , 6 ( 16 ), 6417 - 6430 .

RAN R , YAN H W , ZHANG G L , et al . Elucidating the promotional effects of the Al element on the catalytic performance of Al-Cs/SiO 2 for methyl methacrylate synthesis via one-step aldol condensation [J ] . Industrial & Engineering Chemistry Research , 2024 , 63 ( 35 ): 15404 - 15414 .

张一哲 , 孙建壮 , 赵兴华 , 等 . CaTiO 3 催化正戊醛羟醛自缩合反应性能 [J ] . 精细化工 , 2023 , 40 ( 9 ): 2080 - 2088 .

ZHANG Y Z , SUN J Z , ZHAO X H , et al . CaTiO 3 catalyzed self-condensation of n -valeraldehyde [J ] . Fine Chemicals , 2023 , 40 ( 9 ): 2080 - 2088 .

WU Z Y , SUN T L , LI Z X , et al . Si-modified Cs/Al 2 O 3 for aldol condensation of methyl acetate with formaldehyde to methyl acrylate by chemical liquid deposition [J ] . Industrial & Chemistry Research , 2022 , 61 ( 48 ): 17467 - 17478 .

赖崇伟 , 李洁 , 熊国焱 , 等 . 丙酸甲酯和甲醛合成甲基丙烯酸甲酯的Cs/SiO 2 催化剂的研究 [J ] . 天然气化工—C1化学与化工 , 2014 , 39 ( 6 ): 1 - 4+20 .

LAI C W , LI J , XIONG G Y , et al . Study on Cs/SiO 2 catalyst for synthesis of methyl methacrylate from methyl propionate and formaldehyde [J ] . Natural Gas Chemical Industry , 2014 , 39 ( 6 ): 1 - 4+20 .

王光永 , 鄢义 , 谌晓玲 , 等 . 羟醛缩合制甲基丙烯酸甲酯催化剂的制备, 催化剂及应用 : 109364908A [P ] . 2020-05-19 .

WANG G Y , YAN Y , SHEN X L , et al . Preparation, catalysts and applications of catalysts for aldol condensation to produce methyl methacrylate : 109364908A [P ] . 2020-05-19 .

CHIDCHON S , YANG D , ZHANG G L , et al . One-step aldol condensation of ethyl acetate with formaldehyde over Ce and P modified cesium supported alumina catalyst [J ] . Journal of Industrial and Engineering Chemistry , 2017 , 46 : 342 - 349 .

贾鑫 . Cs/SiO 2 催化合成MMA宏观动力学及再生性能研究 [D ] . 北京 : 北京石油化工学院 , 2023 .

JIA X . Macro-kinetics and regeneration for catalytic production of methyl methacrylate by Cs/SiO 2 [D ] . Beijing : Beijing Institute of Petrochemical Technology , 2023 .

张国梁 . Cs-P酸碱双功能材料制备及其催化合成丙烯酸甲酯工艺研究 [D ] . 北京 : 中国地质大学 , 2017 .

ZHANG G L . Preparation of Cs-P acid-base bifunctional catalyst and its application in synthesis of methyl acrylate [D ] . Beijing : China University of Geosciences , 2017 .

DENG S L , ZHAO K , LI Q , et al . Zirconium-modified Cs/SiO 2 catalyst for synthesis of methyl acrylate via aldol condensation of methyl acetate with formaldehyde [J ] . Industrial & Engineering Chemistry Research , 2024 , 63 ( 36 ): 15707 - 15720 .

DING S , WANG L , YAN R Y , et al . Condensation of methyl propionate with formaldehyde to methyl methacrylate over Cs-Zr-Mg/SiO 2 catalysts [J ] . Advanced Materials Research , 2012 , 396/ 397 / 398 : 719 - 723 .

荆涛 . 丙烯酸甲酯的绿色合成工艺 [D ] . 哈尔滨 : 哈尔滨工业大学 , 2012 .

JING T . Green process for preparation of methyl acrylate [D ] . Harbin : Harbin Institute of Technology , 2012 .

Views

145

下载量

CNKI被引量

Alert me when the article has been cited

提交

Tools

Publicity Resources

Study on Cs/SiO₂ catalyst for synthesis of methyl methacrylate from methyl propionate and formaldehyde

Study on aldol condensation catalyst for methyl methacrylate synthesis

Determination of formaldehyde content in the process of synthesizing methyl methacrylate

Process study on synthesis of ethyl acrylate by vapor phase aldol condensation over Cs/SBA-15

Related Author

DING Mingyue

WANG Guangyong

LAI Chong-wei

LI Jie

XIONG Guo-yan

WANG Li

WANG Guang-yong

LI Rong

Related Institution

Southwest Research and Design Institute of Chemical Industry Co.,Ltd.

State Key Laboratory of Industrial Vent Gas Reuse, National Engineering Research Center for C1 Chemistry, Southwest Institute of Chemical Co., Ltd.

西南化工研究设计院有限公司

School of Chemical Engineering, East China University of Science and Technology

SINOPEC Chongqing SVW Chemical Co., Ltd.

Postal code：610225
Tel：028-85964717 Email：236764603@qq.com
Technical support is provided by Beijing Founder electronics co., LTD 蜀ICP备12008600号-10 蜀公网安备51012202001533
It is recommended to read the content of this site in Chrome&IE9+. Please switch to extreme mode in browser 360.
Cookies We use cookies to help provide and enhance our service and tailor content. By continuing, you agree to the use of cookies.
Total Visits：395733 Visits Today：219

⁰

Study on catalytic performances of Cs-Nb/SiO2 acid-base bifunctional catalysts in aldol condensation to MMA

DOI：10.12434/j.issn.2097-2547.20250168

摘要

Abstract

关键词

Keywords

references

Study on catalytic performances of Cs-Nb/SiO₂ acid-base bifunctional catalysts in aldol condensation to MMA